Car Air-Conditioning

Car Air conditioning (air con)-A busy time of year

Car Air conditioning

Car Air conditioning bring many problems for their drivers

Here in Halifax in the UK, we are experiencing a particularly warm and pleasant summer. We are at the moment in the middle of the main holiday season and trade can be a little hit and

miss. Many of our customers have had their cars serviced in preparation for their summer holidays, so the servicing side of the business can be a little slower this time of year.

However, one of the things that have kept us going in this hot summer is the number of cars with Car Air conditioning systems that break or have never worked for years. The hot weather makes them dig deep into their pockets and have the air con Operating Systems serviced or repaired. The cars that come to my garage with problems are usually older cars and some come to us complaining that they are having strong smells coming from inside the car.

This is due to the Car Air conditioning system not been used often

with a build-up of nasty’s in the evaporator located just behind the dashboard, this consists of molds, fungi and bacteria, that can cause some drivers to feel ill. This problem can be remedied by using an anti-bacterial spray which should get your car back to smelling fresh again.

Unfortunately, the Car Air conditioning system in cars are not covered by warranty and the system will need servicing from time to time when the gas starts to deplete and the air con system stops working properly, leaving the driver hot and sweaty.

For some reason motorists in the UK, where we have four seasons a year switch off their air con systems in the winter time. I do not think they know that you can run the air con and the car heater at the same time and also the smaller cars with the lower engine capacities will use much more fuel and so they switch the air con off.

Car Air conditioning system can dry out if not used

This result is that the system will dry out and start to damage some of the internal parts. Including small “O”, rings that act as seals within the air con system. These are normally lubricated by the “PAG OIL” that circulates within the system when the air con is in use. The consequences of this are the refrigerant gas that is confined to the system . So,will leak out through the broken “O” ring. Causing it not to work.

To find where the leak is we have to re-gas the system . So,and try to find the leak with a special chemical .That we use to show us where the leak is and then repairing the fault.

In fact, this was the case just the other day. A customer called into to see us with a problem with his Car Air conditioning. In fact, it was not working at all. The car was an older Volvo V40 and the customer always switched the air con off in winter. The car was five-year-old and so we started the process of re-gassing the system. So, in order that we could find out what the problem was.

Indeed, we used our special leak detecting tool.

Finding out the place where the gas had leaked more or less straight away. The problem was due to his air con system drying out. Breaking one of the “O” ring seals. This is a common thing with most cars. If the engines do not run then the hoses and other rubber parts will dry out and perish, because of no lubrication exactly the same as the air con system, the “PAG OIL” circulates in the system and oil all the parts when the system is running. The particular “O” ring was located in the high-pressure pipe part of the condenser which had to be removed and a new one fitted. Here at Pellon Autocentre can repair most models of cars air con and heater systems in the Halifax area of West Yorkshire.

Many other things can go wrong with air con but I will cover those when and if they happen in other blogs.

The new “O” ring was fitted and the driver drove away much happier with his nice cool Volvo.

Pellon Tyre and Auto-centre offer car and van servicing and repairs to all makes and models of vehicles. Significantly, we also sell tyres online from our website  . Finally, by using the tyre selector and choosing your tyre size.

Car Air Conditioning in Halifax UK

Car Air Conditioning in Halifax UK

Car Air Conditioning in Halifax UK

In 2024, most models of cars and vans will be equipped with air conditioning. It is not long ago that only the cream of cars, such as the BMWs and Mercedes of this world, were fitted out with this wonderful driving aid. I can remember when cars were either too hot in the summer or freezing in the winter months.

So, as cars developed over the years, there was a battle developing amongst the car manufacturers to improve equipment levels, and this would attract the public to buy their cars.

Fast forward to today, and most car and van models will have air conditioning fitted as standard. Of course, garages such as the one that I own have had to keep up with the never-ending cycle of new equipment to service the air conditioning systems.

Because of emission concerns

Different gases have had to be used in these air conditioning systems The latest gas is known as R1234yf . Older vehicles still use 134a, which will still be in use as long as there is a demand for it.

Car Air Conditioning in Halifax UK
Car Air Conditioning in Halifax UK

Pellon Tyres Limited, which is situated in the town of Halifax in the United Kingdom, provides a variety of services to guarantee the best possible performance from vehicles. One of them is an Air Con Re Gas for your vehicle, which is essential for ensuring that car air conditioning systems are not only maintained but also improved in terms of their effectiveness.

If you notice that the air coming out of the vents is not as cold as it used to be,

If the process of demisting the windscreen is taking longer than usual, if there is a loss in fuel economy that cannot be explained, or if there is an odd scent, these are all indications that you may want an air conditioning repair or service. The following are some of the many advantages that may be gained by ensuring that the air conditioning in your vehicle is operating at its highest possible efficiency:

Enhancement of Cooling Performance: Car Air Conditioning in Halifax UK

The levels of refrigerant in an air conditioning system might decrease with time, which can result in a decrease in the system’s ability to cool effectively. By re-gassing, the correct levels of refrigerant are restored, which guarantees that the air conditioning system will operate at its highest possible efficiency. The outcome is a cooling process that is both more efficient and more rapid, which results in increased comfort for the passengers.

Re-gassing the air conditioner on a regular basis helps to preserve the overall health of the system

which, in turn, serves to extend the total lifespan of the system. A sufficient amount of refrigerant prevents the compressor and other components from experiencing needless strain, which has the potential to lengthen the overall lifespan of the system. This can provide long-term cost benefits by lowering the probability of major system failures, which in turn can contribute to cost reductions.

For the purpose of preventing damage to components, low refrigerant levels might cause the air conditioning compressor to work harder than it should, which can result in increased wear and the possibility of damage. The process of re-gassing helps to prevent problems like these, ensuring that components function within the parameters stated by the manufacturer and lowering the likelihood of expensive repairs being required.

Efficiency with regard to energy consumption: Car Air Conditioning in Halifax UK

An air conditioning system that is adequately charged operates more efficiently. It is possible for the system to chill the air more efficiently while putting less load on the engine if the levels of refrigerant are maintained at the appropriate amounts. It is possible that this will result in enhanced fuel efficiency, particularly during the summer months when the use of air conditioning is frequently increased.

Considerations Regarding the Environment Certain refrigerants

that are used in air conditioning systems have the potential to cause environmental damage if they are allowed to escape into the atmosphere. Re-gassing on a regular basis helps reduce the likelihood of leaks, which in turn contributes to the preservation of the environment by lowering the amount of dangerous substances that are released.

When compared to the process of addressing serious system faults, the process of re-gassing an air conditioning system is a very straightforward and cost-effective maintenance procedure. It is possible for car owners to save money in the long run by doing routine re-gassing because it can assist in the identification and resolution of minor faults before they develop into more serious and time-consuming difficulties.

Comfortable Driving Experience: Car Air Conditioning in Halifax UK

Having sufficient cooling in the car improves the entire driving experience, particularly when the temperature is high. If your air conditioning system is in good working order, it may make driving more enjoyable and minimise fatigue, regardless of whether you are going to be travelling for a long distance or commuting to work.

Compliance with Manufacturer Recommendations:

In order to guarantee the highest possible level of performance, it is common for automobile manufacturers to call for routine maintenance of the air conditioning system, which may include re-gassing. By following these various instructions, it will be easier to maintain the warranty on the air conditioning system and any related components.

It is recommended that you take your vehicle in for a checkup and maybe a refuelling at least once every two years, according to our professional experience. Pellon Tyres Limited will remove the old refrigerant and replace it with fresh refrigerant. Additionally, the system filters and any lubricants will be cleaned or replaced when necessary. As an additional measure, we will examine the state of all of the other components of the air conditioning system.

1234YF Car Air conditioning gas

1234YF Car Air conditioning gas

1234YF Car Air conditioning gas

1234YF Car Air conditioning gas
1234YF Car Air conditioning gas

1234YF Car Air conditioning gas

So, although we are now out of the European Union, there are certain things that we are still aligned with! Of course, one of the continued alignments is for vehicles. This includes a new directive that came into force this January. Consequently, we are referring to a new type of air conditioning gas. So the new gas is known as 1234YF. This new gas will eventually replace the other older gases used in car air conditioning units. So, the old gas was redeemed “not environmentally friendly” and had to be replaced.

Subsequently, the reason is that the old-style gas that we used was damaging the environment when it leaked out of the vehicles. Known as “R134” refrigerant, the old gas was considered a damager to “global warming” and had to be replaced.

In fact, the R134 gas was considered to have a much worse effect on the environment than the dreaded “carbon dioxide.”.

New gas has a higher cost1234YF Car Air conditioning Gas

Of course, like all new product developments, this new gas comes at a higher price for motorists. So, this new gas is the result of years of development and industry research. Initially, the gas has been developed by two manufacturers, so the end costs to the consumer are considerably higher. So the new gas, 1234YF is more expensive than its old counterpart, R134 gas.

Importantly, this cost should level out as other manufacturers make the price more competitive and more vehicles are using the new gas.

Can my garage supply the new gas? 1234YF Car Air conditioning gas

Of course, the answer is yes; your local garage or auto centre will have access to the new  gas. So, here at Pellon Autocentre, we have invested in a new air conditioning gassing machine specifically for re-gassing cars with the new 1234YF gas installed. So, if you know that your car is charged with the new gas, it may be prudent to check with your garage and make sure they are equipped to do the work! Apparently, not all garages have made the investment required.

This could also include the main dealership garages, so its well worth a check before you have a wasted journey. Finally, our image shows a new BMW with air conditioning issues using the new 1234YF air conditioning gas.

Q1: Why is my car’s air conditioning not as chilly as it used to be?
A1: If your car’s air conditioning isn’t as cold as a frosty morning in Yorkshire, it could be for a number of reasons. The most typical cause is low refrigerant levels. A car’s air conditioning system will naturally lose some refrigerant over time. Also, if there is a leak in the system, the refrigerant will escape more quickly. Other possible causes include a dirty air filter or problems with the compressor. It’s similar to attempting to get a nice brew out of an old kettle; sometimes it only has to be cleaned or repaired!

Q2: How frequently should I service my car’s air conditioner?
A2: Regular servicing is essential, just like giving your automobile a good run on the M1. Most manufacturers recommend that you service your air conditioner every two years. Typically, this service includes a refrigerant recharge as well as a leak and bacteria check. Regular servicing will help maintain your car’s air conditioning efficiency and save you money on future repairs.

Q3: Is there a way to keep my car cool without constantly utilising air conditioning?
A3: Absolutely! On a bright day in Blackpool, you may not always want to use air conditioning. Parking in the shade or utilising a parasol can significantly reduce heat buildup in your vehicle. Also, try opening the windows for a few minutes before turning on the air conditioning. This helps to push away hot air, making your air conditioner’s job a little simpler.

Q4: Does using air conditioning effect my car’s fuel efficiency? 1234YF Car Air conditioning gas
A4: Yes, it can. Using air conditioning can raise your vehicle’s fuel usage, particularly at lower speeds. It’s like running with a big backpack: it requires more work and energy. If you’re driving around town, consider using a fan instead. However, at higher speeds, such as on the motorway, the impact on fuel efficiency is less obvious.

Q5: What is the musty scent I get when I switch on the air conditioner?
A5: The musty odour, which is reminiscent of a damp day in the Lake District, is typically generated by bacteria and mould in the system. This might happen when the air conditioner isn’t used on a regular schedule. To combat this, turn on your air conditioner on a frequent basis, even in cooler weather, to keep air circulating and prevent the accumulation of nasties.

Q6: How can I keep my car’s air conditioning system working properly in between services? 1234YF Car Air conditioning gas
A6: To keep your air conditioner operating as smoothly as a cricket ball at Lords, use it on a regular basis. This helps to lubricate the system and avoid leaks. Also, keep your car’s air filters clean because they can affect the efficiency of the air conditioning system. Regular checkups can help keep your vehicle cool and comfortable.